三一挖掘機排故案例匯編

1、三一挖掘機排故案例三一挖掘機排故案例挖機營銷公司客戶服務部編制挖機營銷公司客戶服務部編制2008年3月三一重機三一重機22.27發動機轉速無法調節............................................................................................................413.發動機故障案例............................

2、....................................................................................................423.1挖掘機重載時偶爾憋車熄火后能馬上啟動.........................................................................423.2機器下排氣嚴重，且出現異常響聲....

3、..................................................................................433.3機器冷機熱機都很難起動，必要冷卻液輔助起動..............................................................443.4發動機機油內進水導致機油發白...............................

4、..........................................................453.5機器工作幾分鐘后冷卻液從副水箱中噴出半小時后因冷卻液流失而水溫高................463.6發動機晚上正常第二天不能起機(馬達能帶動發動機運轉轉速足夠)...............................473.7機器在13檔時憋壓熄火高速運轉時機器掉速嚴重機器在冷機時有所好轉......

5、...........483.8發動機機油壓力低熱機低怠速時低于0.05mpa高速時低于0.2mpa.................................493.9發動機機油消耗量過大..........................................................................................................503.10機器在環境溫度低于1

6、0℃時啟動困難或不能啟動但環境溫度高于5℃時起動正常..513.11機器工作10分鐘后發動機溫度達到105度機器不能作業.............................................523.12機器6檔以下作業時煙色正常，7檔以上作業時發動機冒黑煙，隨發運機轉速上升煙色越大，但發動機掉速不明顯...........................................................

7、..............................................533.13機器在低速作業與憋車時有輕微掉速現象當十檔作業憋壓時掉速熄火，熄火能馬上啟動..................................................................................................................................

8、.......................543.14機器在環境溫度超過37℃時工作一兩個小時后水溫過高當環境溫度低于35℃時則不會過熱.................................................................................................................................................553.1

9、5機器在冷機啟動時排煙很重，冒白煙，熱機后正常........................................................563.16機器在工作過程中突然熄火后無法啟動空氣排不干凈...................................................573.17機器冷機熱機都很難起動，必要冷卻液輔助起動..................................

10、..........................583.18發動機下排氣嚴重................................................................................................................594.液壓故障案例..........................................................

11、..........................................................................604.1機器工作時挖掘無力鏟斗空斗處于舀合狀態時掉缸嚴重................................................604.2機器使用過程中發現操縱左行走閥往前單邊行走前，右邊履帶也緩慢向前行走，但操縱左行走閥向后單邊行走時正常，操縱右行走閥單邊行走時正

12、常.............................................614.3機器在向前行走過程中突然出現松開行走操勞過度作手柄后左邊履帶繼續往前行行走拉上液壓鎖定桿后也不能停止向后行走正常但向前行走后故障又出現...................................624.4機器工作過程中突然出現全車無作動現象............................................

13、..............................634.5機器在工作過程中出現動臂下降卡滯現象，其它動作正常..............................................644.6機器工作過程中回轉很慢同時左行走很慢其它動作也同時變慢....................................654.7機器往向行走時，左邊行走很慢，往后行走時機器正常.................

14、.................................664.8調試的過程中，發現此機在不做動作的情況下液壓油溫高的現象，用紅外線測溫儀測量油溫為93℃....................................................................................................................................674.9機

15、器在工作過程中回轉無力，回轉漂移量過大..................................................................684.10機器在斗桿挖過程中，在斗桿與動臂角度在110度至80度之間狀況時會出現停滯3—5秒狀況，其它動作正常...............................................................................

16、..................................695.操作保養案例....................................................................................................................................705.1發動機冒藍煙.................................

17、.........................................................................................705.2發動機排氣口冒黑煙..............................................................................................................715.3挖掘

18、機工作時出現偶爾熄火..................................................................................................725.4風扇葉片打壞水箱...................................................................................................

19、...............735.5大臂銷軸卡死..........................................................................................................................745.6大臂油桿下沉.............................................................